沼氣發電機組使用的時候，遇到動力下降的情況，具體是哪些原因造成的，讓沼氣發電機廠家的小編帶大家共同了解一下。

When using biogas generators, when encountering a decrease in power, what are the specific reasons for it? Let the editor from the biogas generator manufacturer take everyone to understand together.

沼氣動力閥間隙太小，沼氣流量不夠，混合氣過稀。調整動力閥，國Ⅲ系列沼氣發電機組的動力閥裝在減壓器出氣口，動力閥有刻度，R(-)方向?yàn)闇p小，L(+)方向?yàn)榧哟蟆?/p>

The gap between the biogas power valve is too small, the biogas flow rate is insufficient, and the mixture is too thin. Adjust the power valve. The power valve of the National III series biogas generator set is installed at the outlet of the pressure reducer. The power valve has a scale, with the R (-) direction decreasing and the L (+) direction increasing.

檢查沼氣過濾器有無堵塞。

Check for blockages in the biogas filter.

檢查壓力平衡管是否漏氣或破損。

Check if the pressure balance pipe is leaking or damaged.

增壓中冷系統是否有漏氣，檢查排氣管墊、增壓器接口、中冷器、混合器、進氣管及各連接硅膠管，增壓器有無損害。

Check if there is any air leakage in the turbocharged intercooling system, inspect the exhaust pipe gasket, turbocharger interface, intercooler, mixer, intake pipe, and all connecting silicone pipes, and check if the turbocharger is damaged.

排氣管道或三元催化器堵塞，致排氣阻力加大。

Blockages in exhaust pipes or three-way catalytic converters result in increased exhaust resistance.

檢查空氣濾清器是否良好，進氣管路是否暢通。

Check if the air filter is in good condition and if the intake pipeline is unobstructed.

檢查沼氣步進電機及減壓器出氣口到混合器之間的管路。

Check the pipeline between the biogas stepper motor and the pressure reducer outlet to the mixer.

混合器皮膜破損，不能形成合理的空燃比，更換皮膜。

The mixer film is damaged and cannot form a reasonable air-fuel ratio. Replace the film.

中低壓減壓閥二級閥片行程過小。

The second stage valve disc stroke of the medium and low pressure reducing valve is too small.

減壓器電磁閥閥芯、閥孔是否破損，進氣量不夠，更換電磁閥。

Check if the valve core and valve hole of the pressure reducer solenoid valve are damaged, and if the air intake is insufficient, replace the solenoid valve.

檢查低減壓器的膜片、彈簧、桿桿有無損害。

Check for damage to the diaphragm, spring, and rod of the low pressure reducer.

本文由燃?xì)獍l(fā)電機組為您提供，我們的網站是：http://m.kbesw1688.com 我們將以全心全意的熱情為您提供服務，歡迎您的訪問！

This article is provided to you by a gas generator set, and our website is: http://m.kbesw1688.com We will provide you with wholehearted enthusiasm and welcome your visit!